Fire pump inspection report checklist

Template Questions

• Information on this form covers the minimum requirements of NFPA 25 for centrifugal fire pumps. Separ
• Owner:
• Owner's phone number:
• Owner's Address:
• Property Being Inspected:
• Property address
• Date of Inspection: Date
• This Inspection is:
• All responses refer to the current inspection performed on this date.
• Notes: 1) All questions are to be answered Yes, No, or Not Applicable. All NO answers are to be expla
• Part I - Owner's Section
• Note to owner: Periodic tests of transfer switches and emergency generators are to be performed by a
• Owner of Representative (print name):
• Signature and Date:
• A. Inspections
• 7. Electric Motor Driven Pumps
• 8. Diesel Engine Driven Pumps
• f. Record engine running time meter reading.
• A. Electric Motor Driven Pumps
• 1. Weekly Test Items
• Record starting pressure. (PSI)
• Record suction & discharge pressure while running. (PSI)
• 6. Record time for motor to accelerate to full speed.
• 7. For reduced voltage or reduced current staring record time controller is on first step.
• 8. For automatic stop controllers, record time pump runs after starting.
• B. Diesel Engine-Driven Fire Pumps
• Record suction & discharge pressure while running.
• 6. Record time for engine to crank.
• 7. Record time for engine to reach running speed.
• C. Steam Turbine-Driven Pumps
• 1. Record pump starting pressure, suction and discharge pressures while running,
• 5. Record steam pressure gauge reading.
• 6. Record time for turbine to reach running speed.
• Annual pump test was run using the following method.
• 2. Annual Tests
• NOTE: At least once every three years method A or B must be used.
• Suction Pressure:
• No Flow
• Rated Flow
• Peak Flow
• Discharge Pressure:
• Flow Pressure:
• Electric Voltage and Current:
• Pump Speed:
• PUMP TEST RESULTS
• F. Low Suction Throttling Devise Test
• G. Automatic Transfer Switch Test
• H. Alarm Condition Test
• A maintenance schedule must be established in accordance with the manufacturer instructions. In the a
• 1. Weekly Maintenace Items for Diesel Engine Systems:
• C. Maintenance
• 2. Monthly Maintenace Items:
• 3. Quarterly Maintenace Items:
• 4. Semiannual Maintenace Items:
• 5. Annual Maintenance Items
• Notes:
• Inspector Name:
• Company:
• Address:
• I state that the information on this form is correct at the time and place of inspection, and that al
• Inspector:
• Select date Date
• License or Certification Number (if applicable):
• Tested for NFPA 25 Requirements ONLY. Certification DOSE NOT fall within the scope of this inspection
• Inspection & Certification is to be performed by an Alarm Contractor.
• Inspection & Certification is to be performed by Others.
• The property owner or occupant shall not make changes in the occupancey, the use or the material used
• Where changes in the occupancy, hazard, water supply, storage commodity, storage arrangement, buildin